Product ID:Z-6032 SILANE
MSDS Date:03/19/1992
FSC:6850
NIIN:00K000165
MSDS Number: BTHKT

DOW CORNING CORP

3901 SOUTH SAGINAW ROAD
MIDLAND, MI 48640
US

Emergency Phone: 517-496-5900

Info Phone: 517-496-6000

Preparer: JACK L. SHENEBERGER

Cage: 5D028

DOW CORNING CORP

AUBURN, MI 48611 US

Telephone: 517-496-4388

Cage: 71984

METHYL ALCOHOL (METHANOL) (SARA III)

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: 58% %

OSHA PEL S,200PPM

ACGIH TLV: S,200PPM/250STEL; 94

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

N-(3-(TRIMETHOXYSILYL)PROPYL) ETHYLENEDIAMINE

CAS: 1760-24-3

RTECS: KV7400000

Fraction By Weight: 2% %

VINYLBENZYL(TRIMETHOXYSILYL)-PROPYLETHANE-DIAMINE

CAS: 33401-49-9

Fraction By Weight: 40% %

LD50 LC50 Mixture:NOT GIVEN
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:DIRECT CONTACT MAY BURN EYES, IRRITATE
SEVERELY OR PERMANENTLY INJURE. A SHORT EXPOSURE MAY IRRITATE SKIN.
REPEATED, PROLONGED SKIN CONTACT MAY SERIOUSLY IRRITATE AND/OR BURN
MILDLY. MAY CAUSE ALLERGI C REACTION. SHORT VAPOR EXPOSURE MAY
CAUSE DROWSINESS, RESPIRATORY IRRITATION. INGESTIOON MAY CAUSE
BLINDNESS, DEATH.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:BURNS TO EYES, SEVERE EYE IRRITATION, PERMANENT
EYE INJURY, SKIN IRRITATION, SKIN BURNS, ALLERGIC SKIN REACTION,
DROWSINESS, NOSE/THROAT IRRITATION, NERVOUS SYSTEM DISTURBANCES,
UNCONSCIOUSNESS, BLIND NESS, DEATH.
Medical Cond Aggravated by Exposure:OVEREXPOSURE TO ANY CHEMICAL MAY
RESULT IN ENHANCEMENT OF PRE-EXISTING ADVERSE MEDICAL CONDITIONS
AND ALLERGIC REACTIONS.

First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM AND QUIET. GET MEDICAL ATTENTION. SKIN: WASH AFFECTED AREA
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION. EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION. INGESTION: GET MEDICAL ATTENTION. IF
CONSCIOUS, INDUCE VOMITING. LIE DOWN, KEEP WARM AND COVER EYES TO
EXCLUDE LIGHT.

Flash Point Method:CC
Flash Point:55.0F,12.8C
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND
FULL FACE-PIECE SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND CAN
TRAVEL ALONG THE GROUND TO REMOTE IGNITION SOURCES.

Spill Release Procedures:USE ABSORBENT MATERIAL TO COLLECT ANC CONTAIN
FOR SALVAGE OR DISPOSAL. REMOVE ALL SOURCES OF IGNITION AND WEAR
PROPER PROTECTIVE EQUIPMENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP CONTAINER CLOSED AND AWAY FROM
WATER, HEAT, SPARKS AND OPEN FLAME.
Other Precautions:PROVIDE ADEQUATE VENTILATION DURING USE TO CONTROL
EXPOSURES WITHIN LIMITS OR USE RESPIRATORY PROTECTION.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS PER
CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND NIOSH RESPIRATOR
SELECTION.
Ventilation:USE COMBINATION OF LOCAL EXHAUST AND MECHANICAL VENTILATION
TO MAINTAIN EXPOSURE LEVELS BELOW RECOMMENDED LEVELS.
Protective Gloves:RUBBER OR PLASTIC
Eye Protection:CHEMICAL WORKER GOGGLES
Other Protective Equipment:APRONS, BOOTS, EMERGENCY EYEWASH STATION AND
SHOWER.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
NOTE TO PHYSICIAN/MEDICAL PERSONNEL: TREAT FOR METHYL ALCOHOL
POISONING.

HCC:F3
Boiling Pt:B.P. Text:150F,66C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:95
Vapor Density:> 1
Spec Gravity:0.90
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:APPRECIALBE
Appearance and Odor:LIQUID, LITTLE COLOR, SOLVENT ODOR

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS, WATER, HUMID AIR
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES, WATER
Hazardous Decomposition Products:NITROGEN OXIDES AND COMPOUNDS,
CHLORINE COMPOUNDS, SILICON DIOXIDE, CARBON DIOXIDE AND CARBON
PRODUCTS.

Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.